Improved Contacts to MoS2 Transistors by Ultra-High Vacuum Metal Deposition

Abstract

The scaling of transistors to sub-10 nm dimensions is strongly limited by their contact resistance (Rc). Here we present a systematic study of scaling MoS2 devices and contacts with varying electrode metals and controlled deposition conditions, over a wide range of temperatures (80 to 500 K), carrier densities (10^12 to 10^13 1/cm^2), and contact dimensions (20 to 500 nm). We uncover that Au deposited in ultra-high vacuum (~10^-9 Torr) yields three times lower Rc than under normal conditions, reaching 740 Ohm-um and specific contact resistivity 3x10^-7 Ohm.cm2, stable for over four months. Modeling reveals separate Rc contributions from the Schottky barrier and the series access resistance, providing key insights on how to further improve scaling of MoS2 contacts and transistor dimensions. The contact transfer length is ~35 nm at 300 K, which is verified experimentally using devices with 20 nm contacts and 70 nm contact pitch (CP), equivalent to the "14 nm" technology node.

References in corpus (11)

• High Performance Single Layered WSe2 p-FETs with Chemically Doped Contacts
• Mobility engineering and metal-insulator transition in monolayer MoS2
• Chloride Molecular Doping Technique on 2D Materials: WS2 and MoS2
• Towards Intrinsic Charge Transport in Monolayer Molybdenum Disulfide by Defect and Interface Engineering
• Carrier scattering, mobilities and electrostatic potential in mono-, bi- and tri-layer graphenes
• Band-Like Transport in High Mobility Unencapsulated Single-Layer MoS2 Transistors
• Thickness-Dependent Interfacial Coulomb Scattering in Atomically Thin Field-Effect Transistors
• Low Frequency Electronic Noise in Single-Layer MoS2 Transistors
• Molecular Doping of Multilayer MoS2 Field-effect Transistors: Reduction in Sheet and Contact Resistances
• Mobility variations in mono- and multi-layer graphene films
• Trap-assisted space charge limited transport in short channel MoS2 transistor

Cited by in corpus (60)

• Steep-slope Hysteresis-free Negative Capacitance MoS2 Transistors
• Quantum engineering of transistors based on 2D materials heterostructures
• High Current Density in Monolayer MoS${}_2$ Doped by AlO${}_x$
• Energy Dissipation in Monolayer MoS${}_2$ Electronics
• High-Performance Flexible Nanoscale Field-Effect Transistors Based on Transition Metal Dichalcogenides
• How to Report and Benchmark Emerging Field-Effect Transistors
• Strain-Enhanced Mobility of Monolayer MoS2
• Intrinsic Electrical Transport and Performance Projections of Synthetic Monolayer MoS2 Devices
• Uncovering the Effects of Metal Contacts on Monolayer MoS2
• Contact Engineering High Performance n-Type MoTe2 Transistors
• Immunity to Scaling in MoS2 Transistors Using Edge Contacts
• High Current Density and Low Thermal Conductivity of Atomically Thin Semimetallic WTe2
• One-dimensional edge contacts to a monolayer semiconductor
• Atomically Controlled Tunable Doping in High Performance WSe2 Devices
• S2DS: Physics-Based Compact Model for Circuit Simulation of Two-Dimensional Semiconductor Devices Including Non-Idealities
• Nature of carrier injection in metal/2D semiconductor interface and its implications to the limits of contact resistance
• Understanding contact gating in Schottky barrier transistors from 2D channels
• Direct Imaging and Electronic Structure Modulation of Moiré Superlattices at the 2D/3D Interface
• Scaling-up atomically thin coplanar semiconductor-metal circuitry via phase engineered chemical assembly
• Gate tunable WSe2/SnSe2 backward diode with ultrahigh reverse rectification ratio
• Electron irradiation of metal contacts in monolayer MoS${}_2$ Field-Effect Transistors
• Electron transport through metal/MoS2 interfaces: edge- or area-dependent process?
• CMOS-compatible Strain Engineering for High-Performance Monolayer Semiconductor Transistors
• Biaxial Tensile Strain Enhances Electron Mobility of Monolayer Transition Metal Dichalcogenides
• Reduced Thermal Conductivity of Supported and Encased Monolayer and Bilayer MoS${}_2$
• Layer Dependent Interfacial Transport and Optoelectrical Properties of MoS2 on Ultra-flat Metals
• Direct Opto-Electronic Imaging of 2D Semiconductor - 3D Metal Buried Interfaces
• Quantum Transport in Two-Dimensional WS${}_2$ with High-Efficiency Carrier Injection Through Indium Alloy Contacts
• An Inside Look at the Ti-MoS2 Contact in Ultra-thin Field Effect Transistor with Atomic Resolution
• Toward Low-Temperature Solid-Source Synthesis of Monolayer MoS2
• Mechanisms of quasi-van der Waals epitaxy of 3D metallic nanoislands on suspended 2D materials
• Asymmetrically Encapsulated vertical ITO/MoS2/Cu2O photodetector with ultra-high sensitivity
• Titanium Contacts to Graphene: Process-Induced Variability in Electronic and Thermal Transport
• How do Quantum Effects Influence the Capacitance and Carrier Density of Monolayer MoS${}_2$ Transistors?
• Phase Modulators Based on High Mobility Ambipolar ReSe2 Field-Effect Transistors
• Diode-like Selective Enhancement of Carrier Transport through Metal-Semiconductor Interface Decorated by Monolayer Boron Nitride
• Pinpointing the Dominant Component of Contact Resistance to Atomically Thin Semiconductors
• CVD Graphene Contacts for Lateral Heterostructure MoS${}_2$ Field Effect Transistors
• Contact Resistance Optimization in MoS${}_2$ Field-Effect Transistors through Reverse Sputtering-Induced Structural Modifications
• Gate controlled large resistance switching driven by charge density wave in 1T-TaS2/2H-MoS2 heterojunction
• Low-Temperature 2D/2D Ohmic Contacts in WSe${}_2$ Field-Effect Transistors as a Platform for the 2D Metal-Insulator Transition
• Contact-induced doping in aluminum-contacted molybdenum disulfide
• Correlating the Electronic Structures of Metallic/Semiconductor MoTe2 Interface to its Atomic Structures
• Valley-Coupled-Spintronic Non-Volatile Memories with Compute-In-Memory Support
• Mobility and Threshold Voltage Extraction in Transistors with Gate-Voltage-Dependent Contact Resistance
• Room Temperature Single Photon Detection at 1550 nm using van der Waals Heterojunction
• Statistical Analysis of Contacts to Synthetic Monolayer MoS2
• Electrical contact properties between Yb and few-layer WS${}_2$
• A nanogapped hysteresis-free field-effect transistor
• Genuine Ohmic van der Waals contact between indium and MoS2
• Scaling Nanoribbon Transistors with Monolayer Transition Metal Dichalcogenides
• Substrate-Dependence of Monolayer MoS${}_2$ Thermal Conductivity and Thermal Boundary Conductance
• Photo-physics and electronic structure of lateral graphene/MoS2 and metal/MoS2 junctions
• Field-effect at electrical contacts to two-dimensional materials
• Improving Electric Contacts to Two-Dimensional Semiconductors
• Detecting Atomic Scale Surface Defects in STM of TMDs with Ensemble Deep Learning
• Thermal stability of monolayer $W{S}_2$ in BEOL conditions
• Device-to-System Performance Evaluation: from Transistor/Interconnect Modeling to VLSI Physical Design and Neural-Network Predictor
• Scaling Theory of Two-Dimensional Field Effect Transistors
• Enhanced Non-Ohmic Drain Resistance of 2DFETs at Cryogenic Temperature