Mitigating E-beam-induced Hydrocarbon Deposition on Graphene for Atomic-Scale Scanning Transmission Electron Microscopy Studies

Abstract

CVD grown graphene used in (scanning) transmission electron microscopy ((S)TEM) studies must undergo a careful transfer of the one-atom-thick membrane from the growth surface (typically a Cu foil) to the TEM grid. During this transfer process, the graphene invariably becomes contaminated with foreign material. This contamination proves to be very problematic in the (S)TEM because often >95% of the graphene is obscured and imaging of the pristine areas results in e-beam-induced hydrocarbon deposition which further acts to obscure the desired imaging area. In this article, we examine two cleaning techniques for CVD grown graphene that mitigate both aspects of the contamination problem: visible contamination covering the graphene, and invisible contamination that deposits onto the graphene under e-beam irradiation. The visible contamination may be removed quickly by a rapid thermal annealing to 1200 C in situ and the invisible e-beam-deposited contamination may be removed through an Ar/O2 annealing procedure prior to imaging in the (S)TEM.

References in corpus (5)

• Imaging and Dynamics of Light Atoms and Molecules on Graphene
• Suppression of Octahedral Tilts and Associated Changes of Electronic Properties at Epitaxial Oxide Heterostructure Interfaces
• Manipulating low-dimensional materials down to the level of single atoms with electron irradiation
• Single atom manipulation and control in a scanning transmission electron microscope
• Cleaning graphene: comparing heat treatments in air and in vacuum

Cited by in corpus (13)

• Deep Learning of Atomically Resolved Scanning Transmission Electron Microscopy Images: Chemical Identification and Tracking Local Transformations
• Exploring order parameters and dynamic processes in disordered systems via variational autoencoders
• Manifold Learning of Four-dimensional Scanning Transmission Electron Microscopy
• Compressed Sensing of Scanning Transmission Electron Microscopy (STEM) on Non-Rectangular Scans
• Doping of Cr in Graphene Using Electron Beam Manipulation for Functional Defect Engineering
• E-beam manipulation of Si atoms on graphene edges with aberration-corrected STEM
• Insights into radiation damage from atomic resolution scanning transmission electron microscopy imaging of mono-layer CuPcCl${}_{16}$ films on graphene
• Direct-Writing Atom-by-Atom
• Suspended graphene membranes to control Au nucleation and growth
• Reconstruction of the interatomic forces from dynamic Scanning Transmission Electron Microscopy data
• Structure retrieval from 4D-STEM: statistical analysis of potential pitfalls in high-dimensional data
• Electron Energy Loss Spectroscopy of 2D Materials in a Scanning Electron Microscope
• Ultraclean suspended graphene by radiolysis of adsorbed water