Sharp Transition between Coalescence and Noncoalescence of Sessile Drops

Abstract

Unexpectedly, under certain conditions, sessile drops from different but completely miscible liquids do not always coalesce instantaneously upon contact: the drop bodies remain separated in a temporary state of noncoalescence, connected through a thin liquid bridge. Here we investigate the transition between the states of instantaneous coalescence and temporary noncoalescence. Experiments reveal that it is barely influenced by viscosities and absolute surface tensions. The main system control parameters for the transition are the arithmetic means of the three-phase angles, ${\overline{\Theta }}_a$ and the surface tension differences $\Delta \gamma$ between both liquids. These relevant parameters can be combined into a single system parameter, a speciffic Marangoni number $\tilde{M}=3\Delta \gamma /(2\overline{\gamma }{\overline{\Theta }}_a^2)$. This $\tilde{M}$ universally characterizes the coalescence respectively transition behavior as a function of both, the physicochemical liquid properties and the shape of the liquid body in the contact region. The transition occurs at a certain threshold value ${\tilde{M}}_t$ and is sharp within the experimental resolution. The experimentally observed threshold value of ${\tilde{M}}_t\approx 2$ agrees quantitatively with values obtained by simulations assuming authentic real space data. The simulations indicate that the absolute value of ${\tilde{M}}_t$ very weakly depends on the molecular diffusivity.

9 pages, 6 figures

References in corpus (4)

• Symmetric and Asymmetric Coalescence of Drops on a Substrate
• Non-coalescence of sessile drops from different but miscible liquids: Hydrodynamic analysis of the twin drop contour as self stabilizing, traveling wave
• Gradient dynamics description for films of mixtures and suspensions - the case of dewetting triggered by coupled film height and concentration fluctuations
• Droplet actuation induced by coalescence: experimental evidences and phenomenological modeling

Cited by in corpus (8)

• Gradient dynamics models for liquid films with soluble surfactant
• Direct numerical simulation of variable surface tension flows using a Volume-of-Fluid method
• Gradient dynamics model for drops spreading on polymer brushes
• Delayed coalescence of surfactant containing sessile droplets
• Drops on polymer brushes -- advances in thin-film modelling of adaptive substrates
• Binding potential and wetting behaviour of binary liquid mixtures on surfaces
• Capillary filling in drop merging: dynamics of the four-phase contact point
• Drops of volatile binary mixtures on brush-covered substrates