Rethinking Charge Transport and Recombination in Donor-diluted Organic Solar Cells

Abstract

We systematically investigate PM6:Y12 bulk-heterojunction solar cells with donor fractions ranging from 1% to 45%, linking morphology, charge transport, and recombination to device performance. Complementary structural and spectroscopic methods reveal that a percolating PM6 network forms even at below 5% donor content, with lamellar stacking and vertical composition gradients that do not hinder the charge extraction. The reduction of the effective active layer conductivity towards low donor fractions obeys a three-dimensional percolation model, indicating that charge transport is governed by network topology rather without a pronounced percolation threshold. A transition from nongeminate Langevin recombination to a dispersive Smoluchowski-type loss occurs below 5% donor fraction. The latter regime is also nongeminate, i.e., pertains to recombination of the total charge carrier density. Correspondingly, we observe that the Langevin reduction in the higher donor fractions - mostly dominated by redissociation of electron-hole pairs after encounter - changes towards low donor fractions: in these cases, the nongeminate loss rate exceeds the prediction of the Langevin model. This regime coincides with increasing transport resistance due to topology-limited hole conduction, leading to reduced fill factors despite a high retained charge-generation efficiency. Our results demonstrate that strong donor dilution preserves photogeneration if a continuous donor network is maintained, and unveil how topology-controlled transport and non-Langevin recombination jointly define the performance limits of donor-diluted organic solar blends.

References in corpus (10)

• Origin of the Efficient Polaron Pair Dissociation in Polymer--Fullerene Blends
• Origin of Reduced Polaron Recombination in Organic Semiconductor Devices
• Encounter-Limited Charge Carrier Recombination in Phase Separated Organic Semiconductor Blends
• Nongeminate recombination in neat P3HT and P3HT:PCBM blend films
• Comment on "Interface state recombination in organic solar cells"
• On the critical competition between singlet exciton decay and free charge generation in non-fullerene-based organic solar cells with low energetic offsets
• Energy Level Alignment in Ternary Organic Solar Cells
• Transport resistance dominates the fill factor losses in record organic solar cells
• Power-law density of states in organic solar cells revealed by the open-circuit voltage dependence of the ideality factor
• Transport resistance strikes back: unveiling its impact on fill factor losses in organic solar cells