Experimental investigation of turbulent suspensions of spherical particles in a square duct

Abstract

We report experimental observations of turbulent flow with spherical particles in a square duct. Three particle sizes namely: $2H/d_p$ = 40, 16 and 9 ($2H$ being the duct full height and $d_p$ being the particle diameter) are investigated. The particles are nearly neutrally-buoyant with respect to the suspending fluid. Refractive Index Matched - Particle Image Velocimetry is used for fluid velocity measurement even at the highest particle volume fraction (20%) and Particle Tracking Velocimetry for the particle velocity statistics for the flows seeded with particles of the two largest sizes, whereas only pressure measurements are reported for the smallest particles. Settling effects are seen at the lowest bulk Reynolds number $R{e}_{2H}\approx$ 10000 whereas, at the highest $R{e}_{2H}\approx$ 27000, particles are in almost full suspension. The friction factor of the suspensions is found to be significantly larger than that of single-phase duct flow at the lower $R{e}_{2H}$ investigated; however, the difference decreases when increasing the flow rate and the total drag approaches the values of the single phase flow at the higher Reynolds number considered. The pressure drop is found to decrease with the particle diameter for volume fractions lower than $\varphi$ = 10% for nearly all $R{e}_{2H}$. However, at the highest volume fraction $\varphi$ = 20%, we report a peculiar non-monotonic behavior: the pressure drop first decreases and then increases with increasing particle size. The decrease of the turbulent drag with particle size at the lowest volume fractions is related to an attenuation of the turbulence. The drag increase for the two largest particle sizes at $\varphi$ = 20%, however, occurs despite this large reduction of the turbulent stresses, and it is therefore due to significant particle-induced stresses.

References in corpus (13)

• Turbulent channel flow of dense suspensions of neutrally-buoyant spheres
• Transition to turbulence in particulate pipe flow
• Laminar, turbulent and inertial shear-thickening regimes in channel flow of neutrally buoyant particle suspensions
• Shear thickening in non-Brownian suspensions: an excluded volume effect
• The effect of particle density in turbulent channel flow laden with finite size particles in semi-dilute conditions
• Universal Scaling Laws for Dense Particle Suspensions in Turbulent Wall-Bounded Flows
• Drag reduction in turbulent channel flow laden with finite-size oblate spheroids
• Refractive-index-matched hydrogel materials for modeling flow-structure interactions
• Effects of the finite particle size in turbulent wall-bounded flows of dense suspensions
• Aspect ratio effect on particle transport in turbulent duct flows
• Rheology of confined non-Brownian suspensions
• Suspensions of finite-size neutrally-buoyant spheres in turbulent duct flow
• The effect of polydispersity in a turbulent channel flow laden with finite-size particles

Cited by in corpus (10)

• How do the finite-size particles modify the drag in Taylor-Couette turbulent flow
• Particle migration of suspensions in a pressure-driven flow over and through a porous structure
• Finite-size spherical particles in a square duct flow of an elastoviscoplastic fluid: an experimental study
• Buoyant finite-size particles in turbulent duct flow
• On the calibration of Astigmatism particle tracking velocimetryfor suspensions of different volume fractions
• From nearly homogeneous to core-peaking suspensions: insight in suspension pipe flows using MRI and DNS
• Simultaneous Eulerian-Lagrangian velocity measurements of particulate pipe flow in transitional regime
• Near-wall forces on a neutrally-buoyant spherical particle in an axisymmetric stagnation-point flow
• Turbulent pipe flow with spherical particles: drag as a function of particle size and volume fraction
• Turbulence modulation by finite-size spherical particles in Newtonian and viscoelastic fluids