Scalable Nernst Thermoelectric Power using a Coiled Galfenol Wire

Abstract

The Nernst thermopower usually is considered far too weak in most metals for waste heat recovery. However, its transverse orientation gives it an advantage over the Seebeck effect on non-flat surfaces. Here, we experimentally demonstrate the scalable generation of a Nernst voltage in an air-cooled metal wire coiled around a hot cylinder. In this geometry, a radial temperature gradient generates an azimuthal electric field in the coil. A Galfenol (Fe${}_{0.85}$Ga${}_{0.15}$) wire is wrapped around a cartridge heater, and the voltage drop across the wire is measured as a function of axial magnetic field. As expected, the Nernst voltage scales linearly with the length of the wire. Based on heat conduction and fluid dynamic equations, finite-element method is used to calculate the temperature gradient across the Galfenol wire and determine the Nernst coefficient. A giant Nernst coefficient of -2.6 $\mu$V/KT at room temperature is estimated, in agreement with measurements on bulk Galfenol. We expect that the giant Nernst effect in Galfenol arises from its magnetostriction, presumably through enhanced magnon-phonon coupling. Our results demonstrate the feasibility of a transverse thermoelectric generator capable of scalable output power from non-flat heat sources.

arXiv comment14 pages, 4 figures, and Supplementary Information

References in corpus (2)

• Magnon-drag thermopower and Nernst coefficient in Fe, Co, and Ni
• Giant magnetostriction in Tb-doped Fe83Ga17 melt-spun ribbons

Cited by in corpus (16)

• Transverse thermoelectric generation using magnetic materials
• Fermi level tuning and atomic ordering induced giant anomalous Nernst effect in Co2MnAl1-xSix Heusler alloy
• Heat flux sensing by anomalous Nernst effect in Fe-Al thin films on a flexible substrate
• Observation of anomalous Ettingshausen effect and large transverse thermoelectric conductivity in permanent magnets
• High-temperature dependence of anomalous Ettingshausen effect in SmCo${}_5$-type permanent magnets
• Spintronic thermal management
• Creation of flexible spin-caloritronic material with giant transverse thermoelectric conversion by nanostructure engineering
• Combinatorial tuning of electronic structure and thermoelectric properties in Co${}_2$MnAl${}_{1-x}$Si${}_x$ Weyl semimetals
• A mono-material Nernst thermopile with hermaphroditic legs
• Permanent-magnet-based transverse thermoelectric generator with high fill factor driven by anomalous Nernst effect
• Phenomenological analysis of transverse thermoelectric generation and cooling performance in magnetic/thermoelectric hybrid systems
• Origin of negative anomalous Nernst thermopower in Mn-Ga ordered alloys
• Anomalous Ettingshausen effect in iron-carbon alloys
• Seebeck-driven transverse thermoelectric generation in on-chip devices
• Designing flexible hard magnetic materials for zero-magnetic-field operation of the anomalous Nernst effect
• Origin of anomalous temperature dependence of Nernst effect in narrow-gap semiconductors